IFR32140-15000（3C）
产品用途：电动车、储能
产品优点：安全性高、循环寿命长
Product usage:
Product advantages: high safety, long cycle life
基本特性
|
No.序号 |
Item 项目 |
General parameter 常规参数 |
Remark 备注 |
|
1 |
Can Material 壳体材质 |
Ni-plate Steel 镀镍钢壳 |
|
|
2 |
Nominal capacity 标称容量 |
15Ah |
Charge：0.5C5A,3.65V，CC CV 0.02C5ACut-off, Discharge：0.5C5A,2.0V dischargecut-off |
|
3 |
Minimum capacity 最小容量 |
14.5Ah |
|
|
4 |
Nominal voltage 标称电压 |
3.2V |
|
|
5 |
Maximum charge voltage充电最高电压 |
3.65±0.025V |
|
|
6 |
Discharge cut-off voltage放电截止电压 |
2.0±0.05V |
|
|
7 |
Maximum continuous charge current 最大持续充电电流 |
1C5A |
|
|
8 |
Maximum continuous discharge current 最大持续放电电流 |
2C5A |
|
|
9 |
Maximumpulse discharge current 最大脉冲电流 |
6C5A |
10S |
|
10 |
Internal impedance 内阻 |
≤3mΩ |
AC1KHz |
|
11 |
Battery weight 电池重量 |
Approx.295g 约295g |
|
|
12 |
Battery diameter (d) 电池直径 |
33.2±0.2mm |
|
|
13 |
Battery height (h) 电池高度 |
140±0.3mm |
|
|
14 |
Chargemethod 充电模式 |
0.5CC-CV(Cut-off Current 0.05C5A) 恒流恒压，截止电流0.05C5A |
CC/CV |
|
15 |
Rapid charge 快速充电 |
标准充电：0.5C5A Standard charge：0.5C5A 快速充电：1C5A Rapid charge：1C5A |
CC/CV |
|
16 |
Standard discharge 标准放电 |
Standard dischargeConstant Current 0.5C5A,Cut-off Voltage 2.0±0.05V 标准放电持续电流0.5C5A，截止电压2.0±0.05V Max Constant Current 2C5A,Cut-off Voltage 2.0±0.05V 最大持续电流2C5A，截止电压2.0±0.05V |
CC |
|
17 |
Operation temperature（Ambient） 工作环境温度 |
Charge/充电：0℃～60℃ Discharge/放电：-20℃～60℃ |
|
|
18 |
Storage temperature 储存温度 |
Less than 3 months：-20～45℃ More than 3 months：-10～25℃ |
|
电池性能
|
No.序号 |
Test Item 检测项目 |
Test Method 测试方法 |
Test Standard 检测标准 |
|
1 |
Normal temperaturedischarge performance 常温放电性能 |
Standard charge,then rest for 10min and discharge at 0.5C5A、1C5A、2C5Arespectively. 电池标准充电后，搁置10min，然后分别以0.5C5A、1C5A、2C5A放电。 |
Discharge capacity/First cycle capacity×100% 放电容量/首周容量×100% 0.5C5A≥100% 1C5A≥98% 2C5A≥97% |
|
2 |
Normal Temperature Storage 常温荷电保持能力 |
Store for 28days after standard charge,then discharge at 0.5C5A to 2.0V;Then standard charge/discharge cycle for 3times to obtain the recoverable capacity. 电池标准充电后，开路放置28天，然后标准0.5C5A放电至2.0V；再以标准充放电三次测试电池的恢复容量。 |
Residual capacity≥First cycle capacity×95%Recoverable capacity≥First cycle capacity×97% 剩余容量≥首周容量×95% 恢复容量≥首周容量×97% |
|
3 |
Cycle Life 循环寿命 |
The cell is charged at 0.5C5A, and discharged at a constant current of 0.5C5A, then stored 30min.After2000charge-dischargecyclesthe residual discharge capacity is above 80% of first capacity under rate discharge (0.5C5). 将电池进行0.5C5A充电、0.5C5A放电，然后再搁置30分钟。循环2000周后，电池残余容量≥80%*倍率放电下的首周容量 (0.5C5)。 |
≥2000 cycles (Charge:0.5C5A,3.65V,CC CV 0.05C5ACut-off, Discharge:0.5C5A,2.0V dischargeCut-off ) |
|
4 |
Storage Characteristics 储存性能 |
Stored for 12months in room-temperature at 50%DOD.Cell shall be conducted standard charge/discharge cycle for 5 times to obtain the recoverable capacityafter storage. 电池在50%放电深度条件下室温储存12个月后，以标准充放电循环5次，测试电池的恢复容量。 |
Recoverable capacity≥First cycle capacity×90% 恢复容量≥首周容量×90% |
|
5 |
Discharge temperature Characteristics 放电温度特性 |
Standard charged in normal temperature,stored atthe following temperature for 3h,then discharged at constant currentof 0.5C5A. 常温条件下电池标准充电后，电池在放电温度环境中放置3h，然后测试0.5C5A放电的容量。 |
Discharge capacity/First cycle capacity(25℃)×100% 放电容量/首周容量(25℃)×100% -10℃ ≥75%(1.8V) 0℃ ≥85% 55℃ ≥100% |
